HomeNewsArticle Display

Air Force analyzes operational efficiency – one airframe at a time

ARLINGTON, Va. (AFNS) -- Have you ever wondered if the Air Force is flying as efficiently as possible? Well, you’re not alone…and there’s a task force to find out.

The Energy Analysis Task Force, or EATF, led by the deputy assistant secretary of Air Force Operational Energy, has been systematically visiting Air Force bases around the country to observe actual training and mission flights, and speak with flight crews (to include operators and maintainers) about flight operations, practices, and aircraft requirements that have an impact on aviation fuel efficiency. The goal: to identify optimization best practices (and the challenges to implementing them) across each airframe, and produce a report that recommends which initiatives, processes, and technologies could have the greatest benefit to capability and readiness.

Known as a Line Operations Efficiency Analysis, or LOEA, the team starts by targeting one airframe at a time and reviewing applicable publications and in-flight guides for that specific airframe. Then, in coordination with wing leadership, the team visits the aligned bases to conduct in-depth, non-attributional focus groups with aircrews of that airframe.

Led by a team of senior aviators with a breadth of experience across both Air Force and commercial aircraft (many are Reserve Airmen who also fly with commercial airlines), the EATF hopes to gain a better understanding of how crews perceive fuel efficiency efforts, and glean insight about the challenges pilots and maintainers face in their daily operations that may inhibit them from exercising efficiency best practices when the mission allows.

“We understand that the mission comes first – and that the dynamic environment in which we operate does not always allow for the most optimized operations,” said Col. Anthony Brusca, 913th Airlift Group deputy commander at Little Rock Air Force Base, Arkansas, and current lead for the EATF. “We’re here to figure out where there may be a disconnect between training, policy and operations and where there may be opportunities for setting practical efficiency goals that make the lives of Airmen easier.”

Since 2016, the EATF has completed LOEAs on the RC-135 Rivet Joint, E-3 Sentry (otherwise known as AWACS, or airborne warning and control system), C-5M Super Galaxy, C-17A Globemaster III and are currently assessing KC-135 Stratotanker operations.

With the insight gained from these analyses, as well as known industry standards (e.g., best practices for commercial airlines), the team identified a number of processes across airframes that could improve operational efficiency without any capital investment. Examples of these include better utilization of nearby training ranges, enhanced scheduling efficiency, airspeed and altitude optimization, reduced thrust take-off, reduced engine taxi-in, engine washing, and optimized fuel loads, among others.

For the RC-135, the team estimated a potential savings of $1.5 million in fuel costs annually (2 percent of the total fuel cost for the airframe) if these practices were implemented across the fleet. For the E-3, the potential savings were estimated at $9.5 million annually, or 8 percent of the total fuel cost. The C-5M LOEA identified approximately $8.2 million in potential annual savings, and the C-17A LOEA identified approximately $43.2 million in potential savings.

While significant, the EATF emphasized that fuel optimization isn’t just about saving money. “We’re trying to increase capability for the warfighter and make your (Airmen’s) lives easier, and if the protocol in place now doesn’t make sense - and we can explain why – that’s something I want to present to command leadership,” explained Brusca to participating Airmen.

However, with the fluidity of military operations, many Airmen contributing to the focus groups agreed the efficiency standards recommended by the Air Force are not always possible, or realistic in theater, based on current operations. Several participants cited difficulties with ineffective software and fuel gauges, aging equipment and greater mission demands than manpower available as reasons why fuel efficient methods were not always utilized.

Through the LOEA reports, the EATF is looking for a middle ground where Airmen are able to maintain (and even increase) operational effectiveness, while also optimizing fuel use.

For more information on energy optimization efforts in the Air Force, visit: www.safie.hq.af.mil/OpEnergy.

Engage

Facebook Twitter
.@AETCommand's 23rd Flying Training Squadron is transforming the #pilot learning environment, developing vertical-l… https://t.co/I03WAOxZe8
RT @AF_Academy: We're incredibly excited and honored to host the Air Force's 12 Outstanding Airmen over the next few days! 🇺🇸 https://t.co/…
RT @ArmedwScience: #EllsworthAFB is looking for more innovative ways to expand the lifespan of its aircraft. Engineers are using a new deve…
RT @DeptofDefense: .@usairforce loadmasters perform a combat cargo offload qualification as a part of exercise #ThracianFall19 at Cheshnegi…
RT @AirmanMagazine: .@GenDaveGoldfein explains the @usairforce's way-ahead in advanced battle management: Multi-Domain Command and Control.…
Houston -- we are landing October 15 - 17. Cant wait to see what you have to show us! @AggieNetworkhttps://t.co/f3fDo0ntAZ
.@GenDaveGoldfein shares how success in “the future fight” relies on three key components. Find out what they are h… https://t.co/4Hhp3lW1pV
RT @DeptofDefense: “Without us, you live in the dark!” Electricity keeps the mission going at @RAFMildenhall, England. Meet one of the air…
RT @AFSpace: @AirWarCollege faculty members met w/ @US_SpaceCom & AFSPC senior leaders last week. The faculty learned about the challenges…
KC-135 Stratotankers provide the Air Force with global strike & rapid mobility. Like any of our assets we train &… https://t.co/zjATXCfQlN
RT @AF_Falcons: Maybe it will snow in February for the game... Colorado: no need to wait https://t.co/vq7KPsiITx
Cyber security is everyone's responsibility. First step, #BeCyberSmart. https://t.co/mVZr4nJoJK
“There have been some great Airmen, both military and civilian, at Tyndall AFB before, during and after the storm.… https://t.co/EiEga9ur0N
RT @AFSpecOpsCmd: Our community is deeply saddened by the passing of one of our own, TSgt Peter Kraines, a Special Tactics Pararescueman. O…
RT @PACAF: #Airmen with the 31st and 33rd Rescue Squadrons: saving lives is what they do. @KadenaAirBase #Pararescue #HH60 #Readiness #A
RT @HQUSAFEPA: Not our typical #wingman. A butterfly lands on a 31st Aircraft Maintenance Squadron crew chief at #Aviano Air Base, Italy 🦋…
Hey Atlanta, Georgia! #AmericasAirForce will be in your hometown this weekend. Join us for the @AtlantaAirShow, be… https://t.co/oW2L7QoGT3
RT @ncaawrestling: .@AF_Wrestle is building something special and putting in the work on The Terrazzo #LetsFly https://t.co/N4GDrg6uF9 📸:…
RT @AF_SBIR_STTR: The Air Force tech accelerator AFWERX is dangling the prospect of an extra injection of capital for commercial startup fi…